Kia Sportage: Maintenance Schedule / Normal Condition General market

Kia Sportage QL (2015-2024) Service Manual / Maintenance / Maintenance Schedule / Normal Condition General market

Normal Maintenance Schedule - For Gasoline Engine [Except Europe (Including Russia)]

The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is determined by whichever occurs first.

NO.

ITEM

REMARK

Coolant (Engine)

When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at the factory. An improper coolant mixture can result in serious malfunction or engine damage.

Differential oil (rear) (AWD)

Differential oil should be changed anytime it has been submerged in water.

Drive belts (Engine)

•	Adjust alternator, water pump and air conditioner (if equipped) drive belt. Inspect and if necessary repair or replace.

•	Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

Dual clutch transmission(DCT) fluid

Dual clutch transmission (DCT) fluid should be changed anytime it has been submerged in water.

Engine oil and engine oil filter

Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

Engine oil and engine oil filter
(For Diesel Engine)

•	If the recommended oil is not available, replace engine oil and engine oil filter every 20,000 km or 12 months.

•	The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount oil can damage the engine, and such damage is not covered by warranty.

•	This maintenance schedule depends on fuel quality. It is applicable only when using aqualified fuel <"EN590 or equivalent">. If the diesel fuel specifications don't meet the EN590, it must be replaced according to the severe maintenance schedule.

Fuel additives (Gasoline)

Kia recommends that you use unleaded gasoline which has an octane rating of RON (Research Octane Number) 95 / AKI (Anti Knock Index) 91 or higher (for Europe) or Octane Rating of RON (Research Octane Number) 91 / AKI (Anti-Knock Index) 87 orhigher (except Europe).
For customers who do not use good quality gasolines including fuel additives regularly, and have problems starting or the engine does not run smoothly, one bottle of additives added to the fuel tank at every 15,000km (for Europe, Australia and New Zealand)/ 10,000km (except Europe, Australia and New Zealand). Additives are available from your authorized Kia dealer along with information on how to use them. Do not mix other additives.

Fuel filter cartridge (Diesel)

This maintenance schedule depends on fuel quality. It is applicable only when using aqualified fuel <"EN590 or equivalent">. If the diesel fuel specifications don't meet the EN590, it must be replaced more frequently. If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc., replace the fuel filter immediately regardless of maintenance schedule and we recommend that you consultan authorized Kia dealer for details.

Manual transaxle fluid

Manual transaxle fluid should be changed anytime it has been submerged in water.

*10

Spark plug

For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

*11

Transfer case oil (AWD)

Transfer case oil should be changed anytime it has been submerged in water.

*12

Valve clearance

Inspect for excessive valve noise and/or engine vibration and adjust if necessary.We recommend that the system be checked by an authorized Kia dealer.

MAINTENANCE ITEM	MAINTENANCE INTERVALS	Normal Maintenance Schedule - For Gasoline Engine [Except Europe (Including Russia)]
		Number of months or driving distance, whichever comes first
		Months	12	24	36	48	60	72	84	96
		Miles×1,000	10	20	30	40	50	60	70	80
		Km×1,000	15	30	45	60	75	90	105	120
Engine oil and engine oil filter *5		Nu 2.0L MPI	Except Middle East and Central & South America : Replace every 15,000 km(10,000 miles) or 12months For Middle East and Central & South America : Replace every 10,000 km (6,500 miles) or 12 months For China : Replace every 5,000 km (3,000 miles) or 6 months
		Nu 2.0L FFV	Replace every 10,000 km (6,500 miles) or 12 months
		Theta II 2.4L GDI	Except Middle East and Central & South America : Replace every 15,000 km(10,000 miles) or 12months For Middle East and Central & South America : Replace every 10,000 km (6,500 miles) or 12 months For China : Replace every 5,000 km (3,000 miles) or 6 months
Coolant (Engine) *1			At first, Replace 210,000 km (140,000 miles) or 120 months after that, Replace every 30,000 km (20,000 miles) or 24 months
Drive belts (Engine) *3			-	I	-	I	-	I	-	I
Valve clearance *12		Theta II 2.4L GDI	-	-	-	-	-	I	-	-
Vacuum hoses and crankcase ventilation hoses			I	I	I	I	I	I	I	I
Spark plugs *10		Nu 2.0L MPI	Replace every 150,000 km (100,000 miles) or 120 months
		Nu 2.0L FFV	Replace every 40,000 km (25,000 miles)
		Theta II 2.4L GDI	Replace every 150,000 km (100,000 miles) or 120 months
Automatic transaxle fluid (if equipped)			No check, No service required
Manual transaxle fluid (if equipped) *9			-	-	-	I	-	-	-	I
Dual clutch transmission (DCT) fluid (if equipped) *4			-	-	-	I	-	-	-	I
Drive shaft and boots			-	I	-	I	-	I	-	I
Differential oil (rear) (AWD) *2			-	-	-	I	-	-	-	I
Propeller shaft (AWD)			-	I	-	I	-	I	-	I
Transfer case oil (AWD) *11			-	-	-	I	-	-	-	I
Fuel additives (Gasoline) *7			Add every 10,000 km (6,500 miles) or 6months (For Australia and New Zealand : Add every 15,000 km (10,000 miles) or 12months)
Fuel filter (Gasoline), (For china, Brazil)			-	I	-	R	-	I	-	R
Fuel lines, hoses and connections			-	-	-	I	-	-	-	I
Fuel tank air filter			-	I	-	R	-	I	-	R
Vapor hose and fuel filler cap			-	-	-	I	-	-	-	I
Air cleaner filter		Except China, India, Middle East	I	I	R	I	I	R	I	I
Air cleaner filter		For China, India, Middle East	R	R	R	R	R	R	R	R
Exhaust system			-	I	-	I	-	I	-	I
Cooling system			At first, Inspect 60,000 km (40,000 miles) or 48 months after that, Inspect every 30,000 km (20,000 miles) or 24 months
Air conditioner compressor/refrigerant (if equipped)			I	I	I	I	I	I	I	I
Climate control air filter (if equipped)			R	R	R	R	R	R	R	R
Brake discs and pads			I	I	I	I	I	I	I	I
Brake lines, hoses and connections			I	I	I	I	I	I	I	I
Brake/clutch (if equipped) fluid			I	R	I	R	I	R	I	R
Parking brake			-	I	-	I	-	I	-	I
Steering gear rack, linkage and boots			I	I	I	I	I	I	I	I
Suspension ball joints			I	I	I	I	I	I	I	I
Tire (pressure & tread wear)			I	I	I	I	I	I	I	I
Battery condition			I	I	I	I	I	I	I	I

Normal Maintenance Schedule - For Diesel Engine [Except Europe (Including Russia)]

The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for allvehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is determinedby whichever occurs first.

NO.

ITEM

REMARK

Coolant (Engine)

Differential oil (rear) (AWD)

Differential oil should be changed anytime it has been submerged in water.

Drive belts (Engine)

•	Adjust alternator, water pump and air conditioner (if equipped) drive belt. Inspect and if necessary repair or replace.

•	Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

Dual clutch transmission (DCT) fluid

Dual clutch transmission (DCT) fluid should be changed anytime it has been submerged in water.

Engine oil and engine oil filter

Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

Engine oil and engine oil filter
(For Diesel Engine)

•	If the recommended oil is not available, replace engine oil and engine oil filter every 20,000 km or 12 months.

•	The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount oil can damage the engine, and such damage is not covered by warranty.

•	This maintenance schedule depends on fuel quality. It is applicable only when using aqualified fuel <"EN590 or equivalent">. If the diesel fuel specifications don't meet the EN590, it must be replaced according to the severe maintenance schedule.

Fuel additives (Gasoline)

Kia recommends that you use unleaded gasoline which has an octane rating of RON (Research Octane Number) 95 / AKI (Anti Knock Index) 91 or higher (for Europe) or Octane Rating of RON (Research Octane Number) 91 / AKI (Anti-Knock Index) 87 or higher (except Europe).
For customers who do not use good quality gasolines including fuel additives regularly, and have problems starting or the engine does not run smoothly, one bottle of additives added to the fuel tank at every 15,000km (for Europe, Australia and New Zealand)/ 10,000km (except Europe, Australia and New Zealand). Additives are available from your authorized Kia dealer along with information on how to use them. Do not mix other additives.

Fuel filter cartridge (Diesel)

Manual transaxle fluid

Manual transaxle fluid should be changed anytime it has been submerged in water.

*10

Spark plug

For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

*11

Transfer case oil (AWD)

Transfer case oil should be changed anytime it has been submerged in water.

*12

Valve clearance

Inspect for excessive valve noise and/or engine vibration and adjust if necessary.We recommend that the system be checked by an authorized Kia dealer.

MAINTENANCE ITEM	MAINTENANCE INTERVALS	Normal Maintenance Schedule - For Gasoline Engine [Except Europe (Including Russia)]
		Number of months or driving distance, whichever comes first
		Months	12	24	36	48	60	72	84	96
		Miles×1,000	10	20	30	40	50	60	70	80
		Km×1,000	15	30	45	60	75	90	105	120
Engine oil and engine oil filter *4		R 2.0L	For Russia, Australia and New Zealand : Replace every 15,000 km(10,000 miles) or 12months Except Russia, Australia and New Zealand : Replace every 10,000 km (6,500 miles) or 12 months
Coolant (Engine) *1			At first, Replace 210,000 km (140,000 miles) or 120 months after that, Replace every 30,000 km (20,000 miles) or 24 months
Drive belts (Engine) *3			For Russia, Australia and New Zealand : At first, Inspect 90,000 km (60,000 miles) or 48 months after that, Inspect every 30,000 km (20,000 miles) or 24 months Except Russia, Australia and New Zealand : At first, Inspect 80,000 km (50,000 miles) or 48 months after that, Inspect every 20,000 km (12,500 miles) or 12 months
Automatic transaxle fluid (if equipped)			No check, No service required
Manual transaxle fluid (if equipped) *9			-	-	-	I	-	-	-	I
Dual clutch transmission (DCT) fluid (if equipped) *4			-	-	-	I	-	-	-	I
Drive shaft and boots			-	I	-	I	-	I	-	I
Differential oil (rear) (AWD) *2			-	-	-	I	-	-	-	I
Propeller shaft (AWD)			-	I	-	I	-	I	-	I
Transfer case oil (AWD) *11			-	-	-	I	-	-	-	I
Fuel filler cap (Diesel)			-	-	-	I	-	-	-	I
Fuel filter cartridge (Diesel) *8			-	I	-	R	-	I	-	R
Fuel lines, hoses and connections			-	I	-	I	-	I	-	I
Air cleaner filter		Except China, India, Middle East	I	I	R	I	I	R	I	I
Air cleaner filter		For China, India, Middle East	R	R	R	R	R	R	R	R
Exhaust system			-	I	-	I	-	I	-	I
Cooling system			At first, Inspect 60,000 km (40,000 miles) or 48 months after that, Inspect every 30,000 km (20,000 miles) or 24 months
Air conditioner compressor/refrigerant (if equipped)			I	I	I	I	I	I	I	I
Climate control air filter (if equipped)			R	R	R	R	R	R	R	R
Brake discs and pads			I	I	I	I	I	I	I	I
Brake lines, hoses and connections			I	I	I	I	I	I	I	I
Brake/clutch (if equipped) fluid			I	R	I	R	I	R	I	R
Parking brake			-	I	-	I	-	I	-	I
Steering gear rack, linkage and boots			I	I	I	I	I	I	I	I
Suspension ball joints			I	I	I	I	I	I	I	I
Tire (pressure & tread wear)			I	I	I	I	I	I	I	I
Battery condition			I	I	I	I	I	I	I	I

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

Maintenance Schedule

...

Severe Condition General market

Maintenance Under Severe Usage Conditions - For Gasoline Engine [Except Europe (Including Russia)] MAINTENANCE ITEM MAINTENANCE OPERATION ...

Other information:

Kia Sportage QL (2015-2024) Service Manual: Rail Pressure Sensor (RPS) Repair procedures

Inspection 1. Connect the KDS/GDS on the Data Link Connector (DLC). 2. Measure the output voltage and fuel pressure of the RPS at idle and various engine speed. Pressure Output Voltag ...

Kia Sportage QL (2015-2024) Service Manual: Rear Seat Assembly Components and components location

Component Location 1. Rear seat cushion assembly 2. Rear seat back assembly ...